General specifications

Version 3.0 - 01-2020

HILTRA® F90 LABSAVER® Li-ion series (LOADS):

This fire safety cabinet complies with the European standard EN 14470-1/2004, fire resistance 90 minutes. Applicable within PGS 15/Version 1.1 (Sept 2016) Regulation 3.3. The design is specifically adapted for charging lithium-ion batteries and has a passive and active monitoring of the cabinet contents with a special extinguishing cartridge for extinguishing Li-Ion battery fires, an F90 emergency pressure relief hatch with special filter (see below) in the roof surface.

 Certification/Fireproofing cabinet:

• Fire resistance 90 minutes determined in accordance with the European Norm (NEN-)EN 14470-1/2004 by the accredited test institute MPA Dresden.
• Fire resistance tested from the inside at the Battery University in Karlstein.
• Electrical configuration tested and certified in accordance with EN 3140. 

Casing: 

• Cabinet body and door made of zincor steel and powder coated to your choice in: 
• RAL 7035/light gray or (optional)- RAL 1007/narcis yellow or Cabinet body RAL 7035 and door(s) in RAL 1007. Other colors on request.
• Fireproof insulation package manufactured from non-combustible, environmentally friendly materials finished with a white impact and scratch resistant HPL top coat. 
• Interior of the cabinet potential-free earthed to the earth connection point on the cabinet roof.
• Standardly equipped with freely accessible adjusting feet ± 20 mm for leveling the cabinet. 
• The cabinet is equipped with a galvanized steel plate.

Door:

• Front fitted with single or double self-closing sash door with handle placed at ergonomic height. Each door (leaf) lockable by means of a cylinder lock (incl. 2 keys).
• Door rebate provided with fire-resistant strips so that the rebate is hermetically sealed in the event of a fire.

Thermal Door Lock:

• The door(s) equipped with a thermal locking device that locks the door(s) on the inside at a temperature of ± 70 º C. [function: to lock the cabinet until the professional fire department can act] 

F90 Emergency pressure hatch in the cabinet roof equipped with:

• A fire resistant grille which closes automatically in case of fire.
• Special filter to prevent emission of burning li-ion particles from the cabinet. 
• Emergency hatch covered with a cover with flange Ø 125 mm for mutual connection to a vent pipe to the outside air.
• Special filter to prevent the discharge of burning li-ion particles from the box

Fixture:

• Bottom plate in steel, powder-coated RAL 7035/light gray.
• Side walls of the cabinet equipped with steel, powder-coated shelf fixing plate with hook-in grid 50 mm for height adjustment of the shelves. 
• Four (4) removable, galvanized and double PE-coated grid shelves, mesh 35 x 35 mm, in RAL 7032/pebble grey.
• Laying boards rated up to 110 kg with evenly distributed load. 

Recharging device 230V:

• 230V-1F-50Hz/13A - 12 charging positions.
Bus cartridge incl. fire alarm with alarm box contact, contact switch(s) on door and siren/flashlight on roof surface for local alarm.
• Vent fan for heat dissipation
• E-distribution board on side wall incl. circuit breaker. 230V version with shock proof plug.
 

Recharging device 400V:

• 400V-3F-50Hz/13A - 24 charging positions.
• Four wall sockets of 6 charging positions for chargers with LED on/off switch on top 4 layers.
• Blus pattern incl. fire alarm with alarm box contact, contact switch(s) on door and siren/flashlight on roof surface for local alarm.
• Vent fan for heat dissipation
Ventilation openings:.

 

• Integrated ventilation duct with flange connection Ø 80 x H 65 mm on the roof of the cabinet to serve the fan.
• Air vent equipped with a fire damper that closes automatically in case of fire. 

Designation of danger:

• Danger identification by means of the type sticker prescribed in EN 14470-1 with pictograms, symbol: "smoking and open flame prohibited" and "flammable substances" and "ADR 9/batteries".

For more information regarding specifications and options please contact our Sales Department at 0342-404160 or by email.

 

Technical and performance changes reserved.




---